Cornelius Enduro-200/250 Návod k obsluze stáhnout pdf

IMPORTANT:

TO THE INSTALLER.

It is the responsibility of

the Installer to ensure that

the water supply to the

dispensing equipment is

provided with protection

against backflow by an air

gap as defined in

ANSI/ASME A112.1.2-1979;

or an approved vacuum

breaker or other such

method as proved effective

by test.

Water pipe connections

and fixtures directly

connected to a potable

water supply shall be

sized, installed, and

maintained according to

Federal, State, and Local

Codes.

Operator’ s Manual

ICE/BEVERAGE DISPENSER

Model: Enduro 200/250

PRINTED IN U.S.A

IMI CORNELIUS INC; 1995 -- 2000Ó

IMI CORNELIUS REMCOR INC g 500 REGENCY DRIVE g GLENDALE HEIGHTS, IL 60139--2268

Telephone (800) 551--4423 Facsimile (800) 519--4423

Part No.92108

January31, 1995

Revised: September 26, 2000

Revision F

THIS DOCUMENT CONTAINS IMPORTANT INFORMATION

This Manual must be read and understood before installing or operating this equipment

1 2 3 4 5 6 ... 19 20

Shrnutí obsahu

Strany 1 - Model: Enduro 200/250

IMPORTANT:TO THE INSTALLER.It is the responsibility ofthe Installer to ensure thatthe water supply to thedispensing equipment isprovided with protecti

Strany 2 - TABLE OF CONTENTS

10 100 Graphics 92082 Dr Pepper Graphics ED250 Jls 1/16/03 15.083x24.794 10 100 Graphics 92085 7-Up Graphics ED200 Jls 1/16/03 11.083x24.794 1

Strany 3 - MAINTENANCE

792108645576790808793741494398885636826797767922733563465883484612107422917216187230187316728895854555960100741486231517825310172881383772532446676487

Strany 4 - DISPENSER

892108ItemNo. Part No. Name1 21491 Slide, Gate2 22081R Restrictor, Gate3 Not Used4 29541R Plate, Motor Mount5 29694 Agitator6 29555 Cover, Rear Wrappe

Strany 5 - BEVERAGE SYSTEM

992108ItemNo. Part No. Name43 Not Used44 53199 Seal, Motor45 Not Used46 51891 Gasket, Gate47 ***51908 Plug48 71025 Strap, Motor49 620500901 Ice Chute5

Strany 6

1092108ItemNo. Part No. Name77 70068 Washer, 3/8 I.D. x 11/16 O.D. x .070Thk78 Not Used79 71061 Washer, 7/16 I.D. x 1 1/8 O.D. x .063Thk80 70320 Pop R

Strany 7

119210813456891011121415213171816FIGURE 2. ELECTRICAL BOX ASSEMBLYItemNo. Part No. Name1 620022001 Electrical Box (ED250)620020902 Electrical Box (ED2

Strany 8

1292108SOLENOID ASSEMBLY4135286101413121115579FIGURE 3. SOLENOID ASSEMBLYItemNo. Part No. Name1 28173 Arm, Gate Lift2 50754 Bearing, Gate Arm3 32957 S

Strany 9

1392108DRAIN11112334TO COLD PLATEDRAIN ELBOWTO COLD PLATEDRAIN ELBOW1FIGURE 4. DRAIN FOR Z STYLE UNITS WITH COLD PLATESItemNo. Part No. Qty Name1 7075

Strany 10

92108 14WARRANTYIMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanshipunder normal use and service

Strany 11 - DETAIL C

1592108THIS PAGE LEFT BLANK INTENTIONALLY

Strany 12 - No. Part No. Name

i92108TABLE OF CONTENTSPageMAINTENANCE 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Strany 13

One Cornelius PlaceAnoka, Minnesota 55303-6234(612) 421-6120(800) 238-3600Corporate Headquarters:IMI CORNELIUS INC.

Strany 14

192108MAINTENANCEThe following dispenser maintenance should be performed at the intervals indicated:DAILY (or as required)Remove foreign material from

Strany 15

292108DISPENSER1. CLEANING EXTERIOR SURFACESImportant: Perform the following daily.A. Remove the cup rest from drip tray.B. Wash the drip tray with so

Strany 16 - SOLENOID ASSEMBLY

392108BEVERAGE SYSTEM(IF APPLICABLE)CLEANINGWARNING: Disconnect Power Before Cleaning! Do not use metal scrapers, sharp objects orabrasives on the ice

Strany 17 - No. Part No. Qty Name

49210811. For post-mix valves, remove the nozzle and syrup diffuser and clean them in a mild soap solution. Rinsewith clean water, then reinstall the

Strany 18 - WARRANTY

592108WARNING: If repairs are to be made to a product system, remove quick disconnects fromthe applicable product tank, then relieve the system pressu

Strany 19

692108Trouble Probable CauseBEVERAGE NOT SWEET ENOUGH. A. Empty syrup tank.B. Faucet brix requires adjusting.BEVERAGES NOT COLD (UNITS WITH BUILT--INC

Strany 20 - IMI CORNELIUS INC

Part # Corrections/Update Document Unit Type/Model # Manual # ED200/250 ICE/BEVERAGE DISPENSER 92108 Revision 2 8/11/06 Page Item Old Part De