Cornelius R-404A Návod k obsluze

Operator’s ManualFCB POST-MIX DISPENSERWITH V4 FEATURES(R-404A REFRIGERANT)PRINTED IN U.S.AIMI CORNELIUS INC; 1996Part No 312030002May 8, 1996Control

3120300025TOP PANELCONTROL PANEL (2)(SEE FIGURE 2)FACEPLATE RELIEFVALVE (4)CUP RESTDRIP TRAYSIDE PANEL (2)FACEPLATE (4)BACK PANELVENTILATION LOUVERSNO

312030002 6CONTROL PANEL DISPLAY MESSAGES‘‘FILL 1’’ and ‘‘FILL 2’’ Fault Messages.‘‘FILL 1’’ and ‘‘FILL 2’’ fault messages will appear on the message

3120300027DEFROST SYSTEMSNOTE: The automatic defrost, “SLEEP” (SLEEP TIME), and “WAKE UP” (WAKE UP TIME) should beprogrammed into the Unit electronics

312030002 8Automatic Electric Defrost System.The automatic electric defrost system may be programmed into the Unit to occur up to nine different times

3120300029DISPENSED PRODUCT CONDITIONS‘‘OVERRUN’’, AS APPLIED TO FROZEN CARBONATED BEVERAGESOverrun Defined.Overrun is product expansion that takes pl

312030002 10Freezing Affects Overrun.Freezing causes approximately a 10 percent expansion in a dispensed frozen carbonated drink. The degree offreezin

31203000211SECONDARY CO2 REGULATORSThe secondary CO2 regulators, located inside the Unit, control CO2 pressure to the Unit carbonator(s) and theproduc

312030002 128. If freeze cylinder is not full of product, repeatedly pull and release the faceplate relief valve to slowly bleedCO2 from the freeze cy

312030002133. Unfasten safety chain and remove empty CO2 cylinder.4. Position full CO2 cylinder and secure with safety chain.WARNING: To avoid persona

312030002 1410. Syrup Tank Syrup System.Disconnect syrup tank containing syrup from No. 1 syrup system.Bag-in-Box Syrup System.A. Disconnect No. 1 syr

i 312030002TABLE OF CONTENTSPageSAFETY INFORMATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

31203000215 Bag-in-Box Syrup System. A. Remove end of No. 1 syrup pump syrup inlet line from pail of sanitizing solution. B.

312030002 1632. After carbonator water pump cycles off, intermittently pull and release the No. 1 freeze cylinder faceplaterelief valve. This bleeds C

17312030002WARNING: If repairs are to be made to a product system, remove quick disconnects fromthe applicable product tank, then relieve the system

18312030002Trouble RemedyProbable Cause‘‘CO2 OUT’’ FAULT MESSAGEGOES ON DURINGOPERATION.A. CO2 supply turned off orexhausted.A. Open CO2 cylinder shut

19312030002Trouble RemedyProbable CauseCARBONATOR WATER PUMPWILL NOT SHUT OFF.A. Binding, damaged, or dirtycarbonated water tank balancemechanism.A. C

20312030002Trouble RemedyProbable CauseFROZEN PRODUCTCONSISTENCY VARIESEXCESSIVELY (CONT’D).B. Cylinder freeze-up causing iceformation in center of cy

31203000221WARRANTYIMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanship un-der normal use and se

IMI CORNELIUS INC.CORPORATE HEADQUARTERS:One Cornelius PlaceAnoka, Minnesota 55303-6234(612) 421-6120(800) 238-3600

ii312030002TABLE OF CONTENTS (cont’d)PageBAG–IN–BOX SYSTEM 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . S

iii 312030002TABLE OF CONTENTS (cont’d)PageCYLINDER FREEZE-UP. 20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

iv312030002THIS PAGE LEFT BLANK INTENTIONALLY

1312030002SAFETY INFORMATIONRecognize Safety InformationThis is the safety-alert symbol. When you see thissymbol on our machine or in this manual, be

312030002 2THIS PAGE LEFT BLANK INTENTIONALLY

3120300023OPERATOR’S INSTRUCTIONSThis section describes operating controls and indicators, dispensed product conditions, operating characteris-tics, U

312030002 4MS(Forward)><(Backward)DisplayONMOTORSide 1Side 2BLENDON/OFFSYRUP PRIMEOFFERRORRESETManual DefrostMenu/SelectCancel DefrostERFIGURE 2