Cornelius ED 300 BN Návod k obsluze stáhnout pdf

IMPORTANT:

TO THE INSTALLER.

It is the responsibility of

the Installer to ensure that

the water supply to the

dispensing equipment is

provided with protection

against backflow by an air

gap as defined in

ANSI/ASME A112.1.2-1979;

or an approved vacuum

breaker or other such

method as proved effective

by test.

Water pipe connections

and fixtures directly

connected to a potable

water supply shall be

sized, installed, and

maintained according to

Federal, State, and Local

Codes.

Operator’ s Manual

ICE/BEVERAGE DISPENSER

Model: ED 300 BN

PRINTED IN U.S.A

IMI CORNELIUS INC; 1998--2000Ó

IMI CORNELIUS REMCOR INC g 500 REGENCY DRIVE g GLENDALE HEIGHTS, IL 60139--2268

Telephone (800) 551--4423 Facsimile (800) 519--4423

Part No. 620913201

November 16, 1998

Revised: June 8, 2000

Revision C

THIS DOCUMENT CONTAINS IMPORTANT INFORMATION

This Manual must be read and understood before installing or operating this equipment

1 2 3 4 5 6 ... 18 19

Shrnutí obsahu

Strany 1 - Model: ED 300 BN

IMPORTANT:TO THE INSTALLER.It is the responsibility ofthe Installer to ensure thatthe water supply to thedispensing equipment isprovided with protecti

Strany 2 - TABLE OF CONTENTS

8620913201Trouble Probable CauseBEVERAGE NOT SWEET ENOUGH. A. Empty syrup tank.B. Faucet brix requires adjusting.AGITATORS TURN IN OPPOSITE DIRECTIONS

Strany 3 - MAINTENANCE

9620913201ENDURO 300 (ED300) (POST-MIX)FIGURE 1. ENDURO 300 ASSEMBLY1234567891011121314151617192021222324252627282930313233343536373738394041414141414

Strany 4 - DISPENSER

10620913201ENDURO 300 (ED300) (POST-MIX)ItemNo. Part No. Name1 21491 Slide, Gate2 22081R Restrictor, Gate3 27107 Bracket, Lever Depressor4 15213 Agita

Strany 5 - BEVERAGE SYSTEM

62091320111ENDURO 300 (ED300) (POST-MIX)ItemNo. Part No. Name1 29303R Bracket, Gear Box2 15218 Plate, Motor Mount3 29493 Bracket, Motor Mount4 30794 H

Strany 6

12620913201ENDURO 300 (ED300) (POST-MIX)1347569102815141112131613+--+--2345891012121216REDWHTWHITEBLACKREDWHTWHTREDBLKGRN/YELREDREDBLUEBLKORGBLKBLKN.C

Strany 7 - ROTATION ROTATION

62091320113ENDURO 300 (ED300) (POST-MIX)1 256789 1011121314151133447715FIGURE 5. VALVE PANEL ASSEMBLYItemNo. Part No. Name620404201 Valve Panel Ass’y,

Strany 8

14620913201CAPACITORBEVERAGE PANELOPTIONALBEVERAGE TRANSFORMEROPTIONAL ICE LEVELOPTIONALBEVERAGEVALVESMOTOR HEATEROPTIONAL LIGHTGATESOLENOIDN.O.2RECTI

Strany 9

15620913201WARRANTYIMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanship un-der normal use and se

Strany 10 - 620913201

Strany 11 - ENDURO 300 (ED300) (POST-MIX)

IMI CORNELIUS INC.CORPORATE HEADQUARTERS:One Cornelius PlaceAnoka, Minnesota 55303-6234(612) 421-6120(800) 238-3600

Strany 12

i620913201TABLE OF CONTENTSPageMAINTENANCE 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Strany 13

1620913201MAINTENANCEThe following dispenser maintenance should be performed at the intervals indicated:DAILY (or as required)Remove foreign material

Strany 14

2620913201DISPENSER1. CLEANING EXTERIOR SURFACESImportant: Perform the following daily.A. Remove the cup rest from drip tray.B. Wash the drip tray wit

Strany 15

3620913201BEVERAGE SYSTEMSoap solution - use a mixture of mild detergent and warm 100 degrees F potable water.Sanitizing solution - use 1/2 ounce of h

Strany 16 - FIGURE 6. LADDER SCHEMATIC

4620913201e. Rinse the B-I-B disconnects in the sanitizing solution.f. Sanitizing fittings must be attached to each B-I-B disconnect. If these fitting

Strany 17 - WARRANTY

5620913201REMOVAL AND REPLACEMENT OF AGITATORSLEFT HANDAGITATORO--RINGFRONT (VALVE SIDE) VIEW FROM TOP OF DISPENSERRIGHT HAND AGITATORWITH HOLE IN UPR

Strany 18

6620913201THIS PAGE LEFT BLANK INTENTIONALLY

Strany 19 - Anoka, Minnesota 55303-6234

7620913201WARNING: If repairs are to be made to a product system, remove quick disconnects fromthe applicable product tank, then relieve the system pr